Curing without nitrate

Air dried cured meat and salami recipes

Curing without nitrate

Postby Franco » Wed Jan 05, 2005 6:50 pm

Some recipes, most notably those by Hugh Fearnley Whittingstall suggest that curing without nitrate is acceptable, I know the risks involved if you don't use it but what about the taste?

My first bacon ws cured with no nitrate and was vile, far too salty. Has anyone else cured without nitrate and if so what were the results like?

Franco
User avatar
Franco
Site Admin
 
Posts: 627
Joined: Fri Jul 16, 2004 4:12 pm
Location: Bolton, England

Postby the butcher » Wed Jan 05, 2005 7:11 pm

hi franco,
the shop that i worked in a few years back cured his bacon with just salt and demerara sugar,it was only done in the winter months and was then hung in the shop until it was needed,it became so hard it needed to be soaked in water before it could be boned and sliced and even after soaking it was still salty but some of the older customers had aquired a taste for it over the years.
the butcher
Registered Member
 
Posts: 4
Joined: Fri Nov 26, 2004 9:42 pm

colour

Postby Franco » Wed Jan 05, 2005 7:16 pm

The other problem that I found was that the finished product when fried was an unappetising grey colour :cry:


Franco
User avatar
Franco
Site Admin
 
Posts: 627
Joined: Fri Jul 16, 2004 4:12 pm
Location: Bolton, England

Postby the butcher » Wed Jan 05, 2005 7:26 pm

franco,
yes it does stay a grey colour a bit unappetising the first time you see it,
but as we were given bacon sandwiches for breakfast i got to quite like the flavour which in the more mature middles was quite strong.
the butcher
Registered Member
 
Posts: 4
Joined: Fri Nov 26, 2004 9:42 pm

Postby Oddley » Wed Jan 05, 2005 9:19 pm

I have cured brisket with just salt. I think it was 1/2 lb salt to 1 pint water and 14 days in the bottom of the fridge. No spices herbs nothing.

Believe it or not it came out quite well after being simmered in stock for about 2 hours it tasted lovely and not too salty.
User avatar
Oddley
Registered Member
 
Posts: 2250
Joined: Sun Oct 03, 2004 10:58 pm
Location: Lost Dazed and Confused

Parma ham

Postby Franco » Wed Jan 05, 2005 9:26 pm

parma ham is made without nitrates but because sea salt is used which is naturally high in nitrates and a long curing/hanging time is used you get a good red colour. I am going to try this method when I get the time but the final process can take up to 2 years!!

This is a good link to see the process involved.

http://www.prosciuttodiparma.com/eng/info/making/


Franco
User avatar
Franco
Site Admin
 
Posts: 627
Joined: Fri Jul 16, 2004 4:12 pm
Location: Bolton, England

No Cure

Postby Parson Snows » Thu Jan 06, 2005 4:54 am

Over the generations tastes have changed, take a look at any of the old sausage recipes and note the amount of salt added. These days people tend to prefer more flavourful/spicier foods.

Franco you wrote
Some recipes, most notably those by Hugh Fearnley Whittingstall suggest that curing without nitrate is acceptable �. My first bacon was cured with no nitrate and was vile, far too salty


In his defense; taken from HFW �Making Bacon�

This recipe produces a very versatile pancetta-style streaky bacon - strong and concentrated in flavour, a little on the salty side,


Depending upon which research you read it typically takes between 14 % to 20 % salt to have a substantial curing effect.

The butcher wrote
the shop that i worked in a few years back cured his bacon with just salt and demerara sugar,it was only done in the winter months


In the US they stipulate during what times of the year Country Hams may be cured exactly for the same reason. To avoid the temperature causing the meat to spoil before the salt has had any effect.

Franco wrote
The other problem that I found was that the finished product when fried was an unappetising grey colour


It is typically the nitrates/nitrites that give the meat its �cured colour�. The Romans were the first to work out that sea salt with its natural bound nitrates made the meat red.

Hope that this is of some use to you

kind regards

Parson Snows
Heavenly Father Bless us
And keep us all alive
There's ten around the table
And food enough for five... Amen
User avatar
Parson Snows
Registered Member
 
Posts: 760
Joined: Thu Nov 11, 2004 12:46 pm
Location: Bangkok, Thailand

Curing without Nitrites

Postby Parson Snows » Mon Jan 24, 2005 6:24 pm

A nitrite-free meat-curing system.
Canadian Chemical News; 7/1/1990; O'Boyle, Adam R.

Search for more information on HighBeam Research for Meat Curing.
A Nitrite-free Meat-curing System
In North America alone some nine billion pounds of meat are cured annually using sodium nitrite. As a curing agent nitrite performs the following multiple functions:
1. It produces the cooked cured-meat pigment, dinitrosyl ferrohemochrome, which gives cured meat its characteristic pink colour.
2. It gives oxidative stability to meat by preventing lipid oxidation. This effect is complex, but it is believed to be responsible for producing the cured-meat flavour, and preventing the formation of the unpleasant warmed-over flavour which soon becomes apparent in cooked uncured meat on storage. Fat oxidation may also be involved in the differentiation of the flavour of meat from different species by the formation of a rich spectrum carbonyl compounds. However, nitrite is not unique in imparting oxidative stability to meat.
3. Nitrite has an antimicrobial effect which is particularly important in preventing the outgrowth of C. botulinum and the formation of a deadly toxin. However, here too nitrite is not unique.
Nitrite performs all of these functions very well, and has provided mankind with a variety of traditional and well-loved cured-meat products for many centuries. Unfortunately, it also has some serious disadvantages. In meat it forms carcinogenic nitrosamines, nitrosopyrrolidine and dimethylnitrosamine, in the part per billion range (Rubin, 1977). This is particularly true of bacon which reaches a high temperature on frying. On ingestion, nitrite may cause the formation of nitrosamines in the stomach (Wishnok, 1977). Yano et al. (1988) reported that at conditions that we might expect to find in the human stomach (37 [degrees]C and [sub.p]H3) extracts of broiled meats formed substantial levels of mutagens in the presence of nitrite, as measured by the number of revertants formed by S. typhimurium. Although we continue to use nitrite, it is the stated policy of the Canadian and U.S. governments to support the search for a substitute.
We have long recognized that the chance of finding a molecule which duplicates all of the functions of nitrite is infinitessimally small. We therefore decided to devise a multicomponent system for curing meat which, as a whole, would duplicate all the functions of nitrite - colour, oxidative stability and flavour, and preservative effect. In this work we have met with considerable success.
The Cured-meat Pigment
The pigment which gives meat its characteristic cured-meat colour is generally thought to be dinitrosyl ferrohemochrome (DNFH). It is formed from the meat pigment myoglobin, which consists of an iron porphyrin complex, the heme group, attached to the protein globin. In the presence of nitrite the bright red nitrosomyoglobin is formed, in which the H[sub.2]O in the axial position on the heme iron is replaced by nitric oxide, NO. The NO is formed from nitrite by the natural reducing activity of the muscle tissue, which is sometimes accelerated by the addition of reductants such as ascorbic acid. In heat-processed cured meat the globin has been split off to produce the final heat-stable pink pigment.
The structure of DNFH is shown in Figure 1. Lee and Cassens (1976) and Renerre and Rouge (1979) used [sup.15]N-labelled nitrite to independently confirm that the heated pigment contained twice as much [sup.15]N as the unheated pigment. Spectroscopic and theoretical considerations of Tarlagdis (1962) as well as work by Wayland and Olson (1974) lend further support to this interpretation of the structure of DNFH.
In our curing system we decided to preform the cured-meat pigment, and to use it to give meat the characteristic cured-meat colour.
Our basic material for preparing the cured-meat pigment is beef red blood cells, an abundant packinghouse by-product. The blood cells contain hemoglobin, which has the same heme group as myoglobin but differs in the protein portion of the molecule. The preparation of DNFH from hemoglobin involves two steps. The first is the preparation of hemin, an Fe[sup.3]+ porphyrin. Our own variation of the literature methods is described by Shahidi et al. (1984). The cured meat-pigment is produced from hemin using nitric oxide in the presence of a reducing agent (Shahidi et al., 1985). The yield starting with hemoglobin from beef red blood cells was 96%, and the purity was 95-99%.
The absorbance spectrum of the preformed pigment is shown as the top curve in Figure 2. The bottom curve is that of the pigment extracted from nitrite-cured ham. The two absorption maxima of both pigments are at 535 and 563 nm.
Unfortunately, the preformed pigment is unstable to light and air, as is the pigment in nitrite-cured meat. One approach to protecting the pigment prior to application is to use microencapsulation. A good encapsulating agent must be safe as a food additive, it must protect DNFH from oxidation during storage, and release it when required. Carbohydrate-based encapsulating agents have proven to be suitable in our application. In fact, our encapsulated DNFH can now be stored for one year or longer. We have used it successfully in preparing meat products, as will be illustrated later.
Oxidative Stability and Flavour
It has been previously mentioned that nitrite is an excellent antioxidant in meat systems, and that this is important in giving meat the characteristic cured flavour.
The classical technique for determining the extent of lipid oxidation in meat is the 2-thiobarbituric acid (TBA) test, which measures the amount of malondialdehyde formed. In this work we used the standard TBA test, as modified by Shahidi et al. (1987a). We have identified what may in fact be an alternative to the TBA test. Hexanal is the dominant breakdown product of lipid oxidation, and has been assigned a variety of odour characteristics, all unpleasant. Its effect on meat flavour must be substantial. We showed (Shahidi et al., 1987b) that the hexanal content (expressed as % of the hexanel content of the untreated control) and TBA numbers were closely correlated, and there was an indication that both correlated with sensory scores (see Table 1). Our work indicates that the hexanal content, after two days of storage, may be a more suitable indicator of lipid oxidation than the TBA test.
In comparing a number of antioxidants, we found that sodium ascorbate (SA) and sodium tripolyphosphate (STPP) are by themselves inadequate, but together they are highly synergistic giving a reasonably low TBA value (see Table 1). In the presence of a trace of a good phenolic antioxidant the TBA values are excellent, perhaps better than for nitrite. The samples were also evaluated organoleptically for flavour. The uncured control sample received a low sensory score. On the other hand, the sample containing SA, STPP and t-butylhydroquinone (TBHQ) was well accepted, and compared favourably with the nitrite-cured sample.
The Antimicrobial Effect
Nitrite acts as an important preservative in meat products and, as already mentioned, it impedes the outgrowth of C. botulinum. It plays an important role in making cured meats safe unless they are seriously abused. A nitrite-free curing system must duplicate this effect. Fortunately, nitrite is not unique in this regard. Many other agents have been suggested such as potassium sorbate, sodium hypophosphite, propyl paraben, and monomethyl and dimethyl fumarate. In a study at the University of Guelph (Wood et al., 1986) it was shown that each of these substances was an effective antimicrobial agent when used with our nitrite-free meat-curing system. Of these, sodium hypophosphite at 3000 mg/kg perhaps had a slight edge, and is the agent we used in the preparation of nitrite-free products. It is a crystalline salt which is bland in taste and readily soluble in pickle. It is an approved food additive in the United States.
Other alternatives have recently become available. Of these perhaps the most interesting is sodium lactate. The Oscar Mayer Foods Corporation received a patent for its use in meat products to delay the growth of C. botulinum (Anders et al., 1989). Its use in meat products as a flavour enhancer and as a preservative is now in the regulatory approval process in the United States. Sodium lactate is used at a rather high level, 2-3%. It seems to be reasonably effective, and it would certainly be an acceptable food additive.
Production of Wieners
The nitrite-free meat-curing system was tested on a pilot-plant scale for the production of wieners. This report briefly summarizes a large experiment reported in detail earlier (O'Boyle et al., 1990). The meat blocks were used: all-pork, pork with 10% beef, and all-chicken. The test runs were nitrite-free and contained the ingredients of the nitrite-free system - encapsulated DNFH at a level of 35 ppm of DNFH, 30 ppm TBHQ, and sodium hypophosphite at 0.3% of the batch weight. The control runs contained 200 ppm of sodium nitrite. The total weight of each batch was about four kilograms of which the meat constituted 66.7%. The rest was water, salt, binder, seasoning, sodium ascorbate and STPP. This is a fairly typical wiener formulation.
In producing the emulsion a Stephan vertical cutter/mixer with a vacuum attachment was used. The presence of air during the violent cutting and mixing action can cause complete oxidation of the pigment. The emulsions were stuffed out and processed conventionally in a pilot-scale smokehouse. Atomized liquid smoke (Griffith Imperial B) was applied.
The wieners had a fairly typical proximate analysis, although the fat content was somewhat low (about 10% for the chicken wieners and 15% for the others), and the protein somewhat high (15%).
In the evaluation of flavour by a panel of 15 tasters using triangle tests, significant differences were found after one and two weeks of storage. However, no significant flavour preference was ever perceived between the test and control wieners. All of the wieners were often described as being tough and rubbery, as might be expected at a high protein and low fat content, and in the presence of STPP. This tended to distract the panelists from focussing on flavour, as instructed. In fact, flavour-difference comments were highly inconsistent. A flavour-profile panel of six experienced tasters was asked to pinpoint the key flavour differences for the test and control wieners (all pork and pork with 10% beef). No specific flavour difference was found.
In judging internal colour, the Hunter reflectance spectrophotometer was used. The results showed that the nitrite-free wieners were somewhat darker and more red than the control wieners. It was to be expected that the wieners would be somewhat darker, since the DNFH was added to a background colour that was light-brown. The redness can be readily controlled by adjusting the DNFH level. The experimental pork/10% beef wieners were somewhat darker and more red than their all-pork counterparts. This was due to the fact that beef is very rich in myoglobin, and also somewhat more DNFH (45 ppm instead of 35 ppm) was used in this case. It is felt that more beef can in fact be tolerated. The colour readings remained unchanged during the six-week duration of the test.
Visual evidence of the colour quality is presented for nitrite-free chicken wieners on the front cover of the magazine. The photograph on the front cover of the magazine shows that the nitrite-free wieners (top) compare very favourably to the control. They are virtually indistinguishable as far as colour is concerned.
The microbial quality of the wieners was evaluated over a six-week period by total plate counts. There was very light growth for the first four weeks. However there was an unexpected spurt in growth by the end of the sixth week. There was no difference between the test and control wieners. In commercializing the process more microbiological work will have to be done, both in scope and depth.
The oxidative stability of the wieners was followed by the TBA test. It is interesting to note that lipid oxidation was almost completely prevented by the nitrite-free curing system, both when stored in air and vacuum packaged.
Firmness of the wieners was determined by the method of Voisey et al. (1975). All samples were substantially stiffer than normal wieners for reasons already given. The one control batch that did not contain STPP was significantly less firm than the others. In the rest of the tests, there was essentially no difference between the test and control wieners. There is good reason to believe that texture can be controlled by changes in the formulation.
Summary
The nitrite-free curing system can produce wieners which essentially cannot be distinguished from their nitrite-cured controls. The process has been extended to the curing of solid meat cuts such as ham. It is felt that the nitrite-free meat-curing system has the potential to supply the consumer who is concerned about nitrite with a viable alternative.
References
Anders, R.J., Cerveny, J.G. and Milkowski, A.L. 1989. Method for delaying Clostridium botulinum growth in fish and poultry. U.S. Patent 4,798,729. Lee, S.H. and Cassens, R.G. 1976. J. Food Sci. 41: 969. O'Boyle, A.R., Rubin, L.J., Diosady, L.L., Aladin-Kassam, N., Comer, F., and Brightwell, W. Food Technology 1990, 44: 88. Renerre, M. and Rouge P. 1979. Ann. Tecnol. Agric. 28: 423. Rubin, L.J. 1977. Can. Inst. of Food Sci. Technol. J. 10(1): A11. Shahidi, F., Rubin, L.J., Diosady, L.L., Chew, V., and Wood, D.F. 1984. Can. Inst. of Food Sci. Technol. J. 17: 33: Shahidi, F., Rubin, L.J., Diosady, L.L., and Wood, D.F. 1985. J. Food Sci. 50: 272. Shahidi, F., Rubin, L.J. and Wood, D.F. 1987 a.J. Food Sci. 52: 564. Shahidi, F., Yun, J. Rubin, L.J. and Wood, D.F. 1987b. Can. Inst. of Food Sci. Technol. J. 20: 104 Tarlagdis, B.G., 1962. J. Sci. Food Agric. 13: 481. Voisey, P.W., Randall, C.J., and Larmond, E. 1975. Can. Inst. of Food Sci. Technol. J.8:23. Wayland, B.B. and Olson, L.W. 1974. J. Am. Chem. Soc. 96:19. Wishnok, J.S. 1977. J. Chem. Educ. 54: 440. Wood, D.F., Collins-Thompson, D.L., Usborne, W.R. and Picard, B. 1986. J. Food Protection. 49: 691. Yano, M., Wakabayashi, K., Tahira, T., Arakawa, N., Nagao, M., and Sugimura, T. 1988. Mutation Research 202: 119.
Table : Hexanal Content, TBA Numbers, and Sensory Scores of Meat Systems (1) (Shahidi et al. 1987b) (1) The cooked meats were stored at 4 [degrees] C. The additives were sodium ascorbate, SA sodium tripolyphosphate, STPP; butylated hydroxyanisole, BHA; and t-butylhydroquinone, TBHQ.
PHOTO : Figure 1 Shematic representation of the cooked cured-meat pigment dinitrosyl ferrohemochrome.
PHOTO : Figure 2 Absorption pattern of DNFH pigment in 80% acetone-water

COPYRIGHT 1990 Chemical Institute of Canada

I hope that you find this article of some interest to you

kind regards

Parson Snows
Heavenly Father Bless us
And keep us all alive
There's ten around the table
And food enough for five... Amen
User avatar
Parson Snows
Registered Member
 
Posts: 760
Joined: Thu Nov 11, 2004 12:46 pm
Location: Bangkok, Thailand

Tastes or technology

Postby Epicurohn » Mon Apr 11, 2005 3:10 pm

Parson,

I believe cured meats have become less salty as a result of technology and not tastes. With refrigeration there is less need for salt and nitrates/nitrites to preserve food (less, not absolute lack of necesity). In my country there are still many areas with no electricity or erratic service. You can still get cheeses, salted fish and beef with 2-5 mm layers of seasalt on them. This is not only to fully cure the flesh but to keep flies from putting their eggs on the food.

I would speculate that salt cod, herring and similar foods have less salt now than in the old days since it's salted and refrigerated.

David
Epicurohn
Registered Member
 
Posts: 229
Joined: Mon Jan 31, 2005 10:47 pm
Location: Honduras

Postby Bad Flynch » Fri May 06, 2005 1:05 pm

There are those who would argue that meat made with salt only is not cured but simply preserved with salt. Meat made with nitrate and/or nitrite is cured by the nitrate/nitrite. The tendency has been to change the language in order to make the chemistry changes acceptable. "Politically correct" chemistry, if you will.

Most of the older recipes with heavier salt were made that way so that meat would be preserved and not require refrigeration. There are some of us who remember homes without refrigeration. My first memories of a home are those of a simple ice box, where the ice man delivered blocks of ice on a regular basis. If the neighbor upstairs didn't empty the water pan on a regular basis, the ceiling got stained from water overflow.

Yes, tastes have changed, but some of that was designed by our governments during a time when salt was blamed for hight rates of hypertension. The change in tastes is also a result of, not the cause of, the reduction in salt content of cured meats. It is safe to say that the salty meats remain on the market because of the preferences for the cured and salted meat flavors.
B.F.
Bad Flynch
Registered Member
 
Posts: 202
Joined: Sat Apr 23, 2005 10:33 pm
Location: Indian Territory


Return to Recipes for cured meats

Who is online

Users browsing this forum: No registered users and 5 guests